You are currently browsing the tag archive for the ‘rot’ tag.

Eeek!

20170618_164409_New Quay Court20170618_164405_New Quay CourtFor years my lovely gaff cutter has been hanging around next to our massive houseboat project, sadly neglected.  Time to find out what is going on.

I knew that the starboard side deck and after deck had rot, so off they have come, revealing the bones beneath.  It is a painful thing running a circular saw across your boat’s deck.

Well, it’s not too bad.  The eyebrows had to shoot up at the timber selection of some of the deck beams.  My goodness, some serious grain run out, to the point where a couple of the half dovetails have parted.  Still these will be fairly simple to replace.

A bit more thought will have to go into a section of the carline, which is certainly rotten at the top edge.  I’m not yet clear how far it goes, but it may be a case of scarfing in a repair.  I certainly want to avoid replacing sections of it.

The samson posts on the aft deck have decayed sufficiently to weaken them at deck level,  One problem was insufficient clearance between them and the transom, so water has been trapped.  I’ve made a new design that gives me  a bit more clearance.

20170622_181754

The timber I have to hand does not quite fit the new pattern, but I’ve found some that’s close enough and I can get away with a small shim to make up the extra width.

It’s always fun searching around for timber that fits a shape, and then revealing the inside.   This piece is a 5″ thick board of oak I have had hanging around for about twenty years, and the grain matches quite well to the angle between the sloped transom and the more vertical post.  My lovely Sedgewick planer and bandsaw will do the rough work…20170622_185235The worst rot revealed by lifting the decks was unexpectedly in the port quarter block, a sizeable chunk of timber that connects the beam shelf to the transom, provides corner strength and holds one of the large iroko davits.  This is sufficiently decayed to merit complete replacement, so I’m fishing around in the wood pile for something that works.

Deck plywood has arrived from Robbins, and bronze nails, so I’m really looking forward to quick progress!

We’ll see…

Advertisements